THE POTENTIAL UTILIZATION OF COFFEE WASTE OF PT JAVABICA INTO BIO-BRIQUETTE AS ENVIRONMENTALLY-FRIENDLY FUEL

Authors

  • Joshua Luke Tandiono British School Jakarta
  • Sri Endah A. Department of Mechanical & Biosystem Engineering, Faculty of Agricultural Technology, IPB University

DOI:

https://doi.org/10.29122/mipi.v14i3.4225

Keywords:

Bio-briquettes, Biofuel, Used Coffee Grounds, Hot Pressing, Environmentally Friendly, Renewable Energy

Abstract

The coffee industry produces a large amount of waste in the form of coffee grounds, which is about 45% of the processed coffee beans. This research aims to study the potential of waste produced by the coffee industry as an environmentally friendly alternative fuel (green energy) in the form of biomass briquettes. The results show that coffee waste briquettes have a fairly good performance as fuel, are easily burnt, and have an energy content that is almost the same as dry wood. By using the “hot pressing” method in the mechanical pressing machine, bio briquettes with a fairly good density and strength level can be obtained. The briquettes have a heating value of 5169 – 5500 kcal/kg at water content of 12-12.5%, and a density of 0.35 – 0.86 g/cm3.

References

Ciptadi, W. and Nasution, M.Z., Pengolahan Kopi, Fakultas Teknologi Pertanian – IPB, Bogor, 1985.

Aprita, I.R., Produksi bio pellet & bio briket dari ampas seduhan kopi dan cangkang biji kopi dengan dan tanpa pra perlakuan bahan pada berbagai komposisi perekat, Thesis, Institut Pertanian Bogor, Bogor, 2016.

Aditya, I.W., Kajian Kandungan Kafein Kopi Bubuk, Nilai pH dan Karakteristik Aroma dan Rasa Seduhan Kopi Arabika dan Robusta, Thesis, Fakultas Teknologi Pangan, Universitas Udayana, Bukit Jimbaran, 2015.

Khusna, D., and Susanto, J., Pemanfaatan Limbah Padat Kopi sebagai Bahan Bakar Alternatif dalam Bentuk Bricket Berbasis Biomass, Seminar Nasional Sains & Teknologi Terapan III 2015, Institut Teknologi Adhi Tama, Surabaya, 2015.

Agustina, S.E., Densification Technology, Laboratorium Energi dan Elektrifikasi Pertanian, Institut Pertanian Bogor, Bogor, 2006.

Agustina, S.E., and Syafrian, A., Mesin Pengempa Briket Limbah Biomasa, Solusi Penyediaan Bahan Bakar Pengganti BBM untuk Rumah Tangga dan Industri Kecil, Bandung, 2005.

Agustina, S.E., Potensi Limbah Produksi Bio-Fuel Sebagai Bahan Bakar Alternatif, Paper on Konferensi Nasional Pemanfaatan Hasil Samping Industri Bio-Fuel Serta Peluang Pengembangan Industri Integratednya, Jakarta, 2007.

Artati, W.K., Kajian Eksperimental terhadap Karakteristik Pembakaran Brikel Limbah Ampas Kopi Instan dan Kulit Kopi, Thesis, ITS, Surabaya, 2012.

Riseanggara, R.R., Optimasi Kadar Perekat pada Briket Limbah Biomassa, Thesis, Fakultas Teknologi Pertanian IPB, Bogor, 2007.

Darmawan, I., Modifikasi Desain dan Uji Unjuk Kerja Mesin Pengempa Briket Mekanis Tipe Kempa Ulir (Screw Pressing), Thesis, Institut Pertanian Bogor, Bogor, 2008

Downloads

Published

13-09-2023

How to Cite

Tandiono, J. L., & A., S. E. (2023). THE POTENTIAL UTILIZATION OF COFFEE WASTE OF PT JAVABICA INTO BIO-BRIQUETTE AS ENVIRONMENTALLY-FRIENDLY FUEL. Majalah Ilmiah Pengkajian Industri; Journal of Industrial Research and Innovation, 14(3), 203–210. https://doi.org/10.29122/mipi.v14i3.4225

Issue

Vol. 14 No. 3 (2020): Majalah Ilmiah Pengkajian Industri; Journal of Industrial Research and Innovation

Section

Articles

License

Creative Commons License

This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.

Open Access Policy

MIPI provides immediate open access to its content on the principle that making research freely available to the public supports a greater global exchange of knowledge.

MIPI by BRIN is licensed under a Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License. Permissions beyond the scope of this license may be available at http://ejurnal.bppt.go.id/index.php/MIPI